Use of various diathermy techniques to reduce perioperative transfusions and intra operative blood loss have been recommended and a new electrothermal bipolar tissue sealing system (LigaSure) has been used in various type of surgeries. The LigaSure device uses high current, low-voltage, bipolar radiofrequency (RF) energy. Tissue is grasped and compressed within the jaws of the instrument. When sealing is completed, microprocessor-control feedback mechanism automatically terminates electrical current. This device uses body’s own collagen and elastin to create a permanent fusion zone and can fuse vessels up to and including 7 mm, lymphatics, and tissue bundles, and has an average seal cycle of two to four seconds in most surgical situations ( 1 – 4 ).

Total thyroidectomy is the fundamental treatment for benign and malignant thyroid diseases. However, extended resection may increase postoperative complication rates ( 5 ). Bleeding during thyroidectomy surgery may compromise the exposure of the operation site and may lead to damage of the recurrent laryngeal nerve (RLN) and difficult dissection of parathyroid glands, and can extend surgical time. Thyroid surgery requires meticulous devascularization of a large number of blood vessels and plexuses in the parenchyma of the thyroid gland. Therefore, hemostasis is of great importance when dividing various vessels before removing the gland ( 6 ).

Effective tissue hemostasis can be achieved through either conventional suture ligation (CSL) or Ligasure system ( 7 ). Postoperative hemorrhagic complications and hematoma rates are higher in total thyroidectomy as opposed to subtotal thyroidectomy because of the extended dissection and resection ( 5 , 8 , 9 ). The aim of this study was to compare the results of CSL and the LigaSure Precise vessel sealing system in total thyroidectomy.

This retrospective non-randomized clinical trial review included 118 consecutive patients. All patients with a diagnosis of bilateral nodular or multi nodular goiter (MNG) underwent total thyroidectomy by a single surgeon between December 2010 and December 2015. Patients with toxic MNG, thyroid malignancy, intra thorasic goiter and a history of previous thyroid surgery were not included in the study. A fine needle aspiration biopsy was performed preoperatively to exclude malignancy. Written informed consent was obtained from each patient prior to surgery. The ethical approval was obtained from the ethics committee of The Recep Tayyip Erdogan University Educational and Research Hospital in Rize. The approval number for ethic committee is 2018/168.

The data of age, sex, surgical time, length of hospital stay, transient/permanent RLN palsy, transient/permanent,postoperative hematoma, hypocalcemia, and hoarseness were received. Hypocalcaemia was defined as serum calcium level less than 8 mg/dL. Permanent hypo calcemia was defined when a medical regimen was required for longer than 12 months.

Vocal cord paralysis was defined as complete immobility of the vocal cord. If postoperative RLN palsy was detected, the patient was referred to an ear otolaryngologist. All patients with hypocalcemia and recurrent laryngeal nerve paralysis were examined at 12 months postoperatively. RLN palsy lasting more than 12 months was classified as permanent injury. Intraoperative hemorrhage and postoperative drainage volumes were not included due to the retrospective nature of the study.

The patients were divided into two subgroups; CSL was used as the conventional method together with monopolar and bipolar cautery in group 1, and LigaSure® Precise (L) (Covidien, Boulder, CO, USA) was used as a sealing system for all surrounding tissues of thyroid gland including superior and inferior pole vessels in group 2. A drain was used at the end of surgery in accordance with the nature and necessity of the surgical procedure.

The study consisted of 118 patients [98 females (F) and 20 males (M)]. The mean age was 38.1 (range, 21-67) years. The CSL group comprised 60 patients (49F, 11M) and L group consisted of 58 patients (49F, 9M). The mean age was 39.4±1.25 years in CSL group, and 36.7±0.95 in the L group, 38.1 years across both groups. No statistically significant differences were found between the two groups with respect to age and sex. The mean surgical time was 48.1 minutes in the CSL group, 44.3 minutes in the L group, and 46.2 minutes across both groups. The mean length of hospital stay was 1.7 days in CSL group and 1.88 in the L group (Table-1). Transient hypocalcemia was seen in four patients (6.6% in the CSL group, 6.9% in the L group; 6.8% in total) in each group. Permanent hypocalcemia was observed in only one patient (1.6%) who was in the CSL group. Transient RLN palsy occurred in one patient (1.6% in the CSL group, 1.7% in the L group; 1.6% in total) in each group. No permanent RLN palsy was noted in either group. Transient and permanent hypocalcemia and RLN palsy in groups were not significantly different. Hematoma was observed in three patients (5%) in the CSL group, and 2 in (3.4%) the L group; 4% in total (p=0.065). Hoarseness was observed in one patient (1.6% in the CSL group, and 1.7% in L; 1.7%) in each group. Hematoma and hoarse ness were not statistically significant (Table-2).

Sutureless thyroid surgeries have gained increasing importance in the last decade. The efficacy and safety of Harmonic-Scapel® and LigaSure® have been proved in various studies ( 10 – 14 ). Many studies showed that in modern thyroid surgeries, different clinical results are present with the use of different types of hemostatic methods. These results have clinical significance and can be useful for making guidelines for thyroidectomy. There are many studies of patients comparing L with CSL for total thyroidectomy. Much is known about safety of this relatively new technique. However, results regarding surgical time, hospital stay, and intraoperative and post operative complications are controversial. Some studies reported that the Ligasure system decreased both surgical time and hospital stay ( 13 , 15 ). Unilateral or bilateral RLN injury is major and most feared complication after thyroid and parathyroid surgery ( 16 ). It can be either transient or permanent. Reported permanent RLN palsy rate in the literature is 0 to 14% ( 17 ), whereas transient injuries are observed in between 1% and 30% of cases depending on various studies and the frequency of postoperative otolaryngological controls ( 18 – 20 ). Furthermore, vocal cord paresis may appear without injury of the nerve. Merely intense stretching during the retraction of the thyroid gland can cause this transient paresis ( 21 ). Transient injuries usually have different healing times. Full recovery usually lasts 4 to 6 weeks. However, it can be extended up to 12 months. Non-function or dysfunction lasting more than 12 months is considered as permanent injury ( 22 ). Iatrogenic injury to the parathyroid glands resulting in hypocalcemia can occur due to damage through inappro-priate surgical dissection and manipulation of the parathyroid glands.

Postoperative hypocalcemia is the most common event following a total thyroidectomy. Transient and permanent hypocalcemia rate after total thyroidectomy has been reported as 5% to 15% ( 23 , 24 ). Most of the postoperative hypo calcemia is transient, however it may causes long-term hospitalization and decreases quality of the life ( 25 ). Subnormal parathyroid hormone level and calcium replacement requirement with or without calcitriol more than one year after total thyroidectomy is defined as permanent hypoparathyroidism; otherwise it is considered as transient hypocalcemia ( 25 ). Sandonato et al. ( 26 ) were the first to describe the use of Ligasure in thyroidectomies, reporting a decrease in transient RLN injuries and hypoparathyroidism complications. There are some previous studies comparing L with STL techniques for total thyroidectomy. In one of them, Monouras et al. ( 27 ) reported that the use of Ligasure in total thyroidectomy decreased surgical time only. No statistically significant differences were found for intra operative and postoperative complications, postoperative serum calcium measurements, and hospital length of stay between their two groups. Petrakis et al. ( 15 ) observed fewer complications; a shorter surgical time and postoperative hospital stay, and decreased temporary RLN injury and hypocalcemia in their L group. Barbaros et al. ( 13 ) reported reduced hospital stay and surgical time and similar complication rates in their L group. Cakabey et al. ( 17 ) also reported shorter surgical duration and similar complication rates in their L group. According to these authors, the change in technique with Ligasure facilitates dissection of the thyroid lobes and helps to reduce surgical time. They also claimed that a decreased requirement for lateral skin retraction and the reduction in incision length in the L group probably reduced the postoperative pain ( 17 ). Postoperative pain was not evaluated in the present study. In contrast, there were no significant difference in surgical time, RLN injury, hypocalcemia, and hematoma between groups in some other reports ( 6 , 28 – 31 ).

In the present study, two different techniques were compared at one medical center and the surgeries were performed by the same experienced surgeon. All surgeries were performed either with CSL or the LigaSure device. Both groups were eligible for the comparison of comorbidity, diagnosis, and surgical procedures. We found that the use of LigaSure did not significantly reduce surgical time or hospital stay. Moreover, postoperative hypocalcemia, RLN palsy, hematoma, and hoarseness rates were statistically similar with both techniques. We observed only one temporary RLN injury in each group (2/188, 1.7 %). RLN injury was evaluated by indirect laryngoscopy examination performed by the consultant ear, nose and throat surgeon. Temporary RLN injuries were healed at 3 and 5 postoperative months respectively. Permanent RLN palsy was not observed. Temporary hypocalcemia was observed in four patients in each group and only one permanent hypocalcemia was seen in the CSL group. Transient hypocalcemia was maintained with daily calcium carbonate+ cholecalciferol tablets and were resolved at 3,5,7 and 9 postoperative months. Calcium carbonate + cholecalciferol tablet and Calcitriol capsule were used in permanent hypocalcemia.

The use of LigaSure did not increase the risk of RLN palsy and hypocalcemia in our study. These results are consistent with the literature data ( 24 , 26 ). All patients underwent surgery by the same single surgeon, one who specializes in CSL thyroid surgery and achieves quick and safe dissections owing to the acquired level of skill and experience. This probably helped in the low level of RLN palsy and hypocalcemia. A surgeon with the same level of skill and experience should have little difficulty in learning how to use the LigaSure device and accordingly would not expect to increase postoperative complications in anatomic thyroid dissection.

Postoperative hematoma rates were 1.5% in the literature ( 29 , 31 ) and 5.4 % (3 in CSL and 2 in L group) in our study. We attributed this rate to the ineffectiveness of the drains. Hematomas were confirmed by ultrasound and no surgical drainage was required in these patients. Hoarseness due to nerve damage is also a feared complication. Hoarseness can resolve within months. Transient hoarseness rates are 5 to 7% and permanent hoarseness rates are 0.9 to 2.4 % ( 32 , 33 ). In our study, only one patient from each group was observed to have hoarseness, which resolved after a short while. Hoarseness was probably due to compression with the intubation tube in our study. The cost effectiveness of LigaSure is another subject for investigation. We did not evaluate the cost of the Ligasure device in this study. However, some studies suggest that using Ligasure is more expensive than CSL, but this may be reduced by using one device for several patients ( 12 , 17 ). Ligasure device was used in multiple cases after sterilization with ethylene oxide in our study.

We think that previous surgical experience and the applied surgical technique are very important. Studies comparing thyroidectomy techniques have conflicting results; some techniques were reported superior, whereas other researchers documented similar results. There were also similar results in the study. As is well known, millimetric thyroidal arteries and venules that are undetectable during surgery can subsequently cause hematomas and seroma. Facing these complications in the past, both in residency training and in the years of specialization, ensures caution in the following years. We suggest that experience of CSL thyroidectomy is effective for careful thyroidectomy with Ligasure.

There are certain limitations to this study. The studied group consists of a small number of patients and the study has a retrospective design. Therefore, the results of study should be evaluated by studies with large patient populations and more conclusive designs. Nevertheless, it has also some advantages; the number of patients in the groups were similar, all patients underwent surgery by the same experienced surgeon, and total thyroidectomy procedures were applied to all patients.

Using LigaSure for thyroid surgery is safe and effective when evaluated in terms of complications, but it is not superior to CSL and did not reduce the hospital stay or surgical time in the present study. We believe that the surgical products developed by the industry will certainly benefit the health system. However, we suggest that reports which claim that industrial products are indispensable or superior to conventional methods in surgery need to be reviewed and evaluated well.